Dry Screening Tests Conducted With a Bivi-tec Screen
200820 pages
Screening trials at two South African collieries, one on a small test unit and one on a full scale installation, for plant staff handling fine, damp coal.
Fine coal was screened at small apertures while surface moisture stayed below about 5 per cent. Above that, fines adhered to the coarser particles and screening became very difficult. The dual vibrating polyurethane mats stopped blinding and clogging, so screening area stayed available, but the screen action still could not dislodge fines from very damp coal.
Contents
- EXECUTIVE SUMMARY2
- 1. Introduction4
- 2. Bivi-Tec screen5
- 3. Test work at Leeuwpan7
- Results obtained7
- 4 The influence of moisture on screening9
- 5 Bivi-tec Screen at New Clydesdale Colliery14
- 6 Conclusions19
- 7 Acknowledgement20
- 8 References20
How it opens
Dry screening of fine coal at small screen apertures is known to be difficult. Blinding and clogging of the screen surface occurs and the screening efficiency can be very low. The Bivi-tec screen has been named as a possible solution for dry screening of fine coal since the dual-vibratory polyurethane mats eliminate blinding.
How it concludes
R1500,00
Description
Related Products
Create Sedimentological and Structural Models to Assist in Identifying Geological Features That Impact on Mining
2001
Regional geology mapped in three dimensions from borehole data supplied by three mining groups, built for mine geologists and planners assessing seam disruption before layout design.
What this report foundA three dimensional model of the northern Witbank and Highveld coalfield was built from more than 1100 borehole logs, with strata sorted into 13 major...
R1500,00
A three dimensional model of the northern Witbank and Highveld coalfield was built from more than 1100 borehole logs, with strata sorted into 13 major groupings and surface topography taken from satellite elevation data. It runs on open source visualisation software rather than a commercial package. Delays limited coverage to about a quarter of the coalfield.
BCI Chemical Research & Analysis – Calcium & Magnesium
2012
Desk research on two mine water by products, closing out the economic analysis behind proposed brine treatment plants, for readers judging whether recovered salts can be sold.
What this report foundPrices for calcium and magnesium sulphate are recorded for South Africa and for world markets as at mid 2012, together with price trends and the groundwater...
R1500,00
Prices for calcium and magnesium sulphate are recorded for South Africa and for world markets as at mid 2012, together with price trends and the groundwater chemistry that governs which salts a mine water stream will yield. The figures were assembled to support feasibility studies on a eutectic freeze crystallisation plant and an ion exchange plant.
Characterization of Spontaneous Combustion Emissions
2005
Aircraft and ground monitoring at a working colliery in summer and winter, measuring trace gases and particulates from spontaneous combustion, for air quality management and mine planning.
What this report foundAircraft and ground based measurements at Kleinkopje Colliery showed spontaneous combustion to be a significant source of fine particles, with PM2.5...
R1500,00
Aircraft and ground based measurements at Kleinkopje Colliery showed spontaneous combustion to be a significant source of fine particles, with PM2.5 concentrations 91 per cent higher inside a combustion plume than outside it. Sulphur dioxide, nitrogen dioxide and carbon dioxide were also raised in plume, and benzene and toluene were detected. Average particle size was below one micron.